Prefilling and storage considerations for insulin, flu clinics

By: April 21st, 2010 Email This Post Print This Post

Last week’s post on prefilling and storing syringes drew a number of comments from the home health crowd, expressing concern that insulin is often drawn up and stored for patients in that setting. Others wondered what the best-practice is during flu clinics where several syringes at a time are filled to speed the process.

First the flu clinic question. The CDC’s National Center for Immunization and Respiratory Diseases strongly discourages the practice of prefilling influenza vaccines in large quantities, although a limited amount of vaccine may be predrawn under certain circumstances (see guidelines under “Influenza Clinics and Prefilling Syringes”).

What typically happens at these flu clinics is a group of people will be drawing up and labeling the vaccine at one table and it is delivered by trained volunteers to the proper tables for giving the vaccine. Once, drawn up it must be used during that clinic, so as they get closer to the end they will quit drawing up the vaccines until they need them. This procedure is done in a closed monitored setting with trained personnel.

Insulin, on the other hand, is more unique. Many people have gone to the insulin pens so the risk of contamination and wrong dose is lessened.

If you are not using insulin pens the first step would be to check the manufacturer’s recommendations. Some syringe manufacturers discourage prefilling and storage of any medication, including insulin. Additionally, there are many different types of insulin and pre-mixtures, all of which may have different requirements.

For example, a commentary written by Martin M. Grajower, MD, from the department of medicine/endocrinology at Albert Einstein College of Medicine, in Riverdale, NY, published in the September 2003 issue of “Diabetes Care,” indicated that Lantus (made by Aventis Pharmaceuticals) should not be prefilled because it can interact with the plastic in the syringe and begin breaking down.

Additionally BD has this recommendation for their syringes: “BD does not recommend that any of our syringes be prefilled more than a few minutes in advance of the injection. There are no conclusive studies to determine the safety or risks associated with this practice.”

According to “Diabetes Education & Management in Home Care,” regular and NPH insulin can be prefilled for up to 30 days; although it’s recommended to use the insulin within seven days, says Lu Post, RN, MN, COS-C, president of Home Care Institute, LLC and contributor to OASIS-Central, a Beacon Health resource (a division of HCPro) for home healthcare professionals. Mixed insulin however, needs to be used immediately because longer-acting insulin can cause faster-acting insulin to work more slowly, especially with the presence of zinc protamine.

Simply put, as with most recommendations, check with both the syringe manufacturer and the insulin manufacturer to be sure you are operating under appropriate best-practices.

Comments

By Janet Woods on April 21st, 2010 at 12:00 pm

I have been told in the past that part of the reason for not prefilling syringes is the adherence of the medication to the wall of the plastic syringe, thus reducing the medication’s efficacy. Is that true? If so, that would substantiate BD’s recommendation and possiblye change vaccine administration protocols for large groups, etc.

By Kathy Manus on June 2nd, 2010 at 11:07 am

I work in a dental practice and the hygienist pre-fill syringes with chlorhexidine to be used as irrigation following soft tissue managment procedures. Thes syringes are often pre-filled and stored 1 – 2 weeks at a time. I am requesting comments on this practice. Thank you.

By betty von Kohn on June 9th, 2010 at 1:09 pm

I wanted to ask about prefilling of contrast dye using straw method and open containers of dye rather than using the stopper. I would think safe infection practices would require open containers to be mixed under class 5 hood. Should you only prepare using closed syringe or other closed method for use for IV contrast? How about storing dye in warmer for future administration? Is this acceptable to draw up in syringe used in injectors and then warm for future IV use?

 

Leave a Comment

*

« | Home | »

Subscribe - Get blog updates via e-mail

Popular

What are some of your top training tips?

April 24, 2014
by: John Palmer • Uncategorized

Are you ready for National Nurses Week?

April 17, 2014
by: John Palmer • Uncategorized

CMS rule could hit the little guys where it hurts

April 15, 2014
by: John Palmer • Uncategorized

Tactics to get employees to take OSHA seriously

April 7, 2014
by: John Palmer • Uncategorized

Chemical hazards are everywhere – take stock!

March 28, 2014
by: John Palmer • Uncategorized

Safety tips to warm the soul (Soon, I hope!)

March 25, 2014
by: John Palmer • Uncategorized

  • HCPro Broadcast Events Calendar

hcpro.com